Westinghouse WBRCNG140W Specifications

WHL-012 REV. 12.17.14 Gas Fired Residential Combi Boiler Wall Mou

10 WHL-012 REV. 12.17.14 C. GAS Should overheating or gas supply f

11 WHL-012 REV. 12.17.14 PART 3 – TECHNICAL SPECIFICATIONS MODEL R

12 WHL-012 REV. 12.17.14 Figure 1 –Specifications and Dimensions

13 WHL-012 REV. 12.17.14 Figure 2 – Components NUMBER COMPONENT D

14 WHL-012 REV. 12.17.14 Cold weather handling – If appliance has

15 WHL-012 REV. 12.17.14 4. Gas control system components must be

16 WHL-012 REV. 12.17.14 Always take future maintenance into cons

17 WHL-012 REV. 12.17.14 PRODUCTS TO AVOID AREAS LIKELY TO HAVE C

18 WHL-012 REV. 12.17.14 I. WALL-MOUNTING THE APPLIANCE The appli

19 WHL-012 REV. 12.17.14 4. Reinstall the DHW inlet filter. 5. Re

2 WHL-012 REV. 12.17.14

20 WHL-012 REV. 12.17.14 PART 5 – VENTING Vent this appliance in

21 WHL-012 REV. 12.17.14 Figure 8 – Vent Termination Detail DESC

22 WHL-012 REV. 12.17.14 APPROVED EXHAUST VENT AND INTAKE PIPE MA

23 WHL-012 REV. 12.17.14 Vent adaptors are not designed as load-b

24 WHL-012 REV. 12.17.14 E. VENT TERMINATION 1. Two Pipe Roof and

25 WHL-012 REV. 12.17.14 2. Direct Vent, Optional Horizontal and V

26 WHL-012 REV. 12.17.14 PART 6 – INSTALL THE CONDENSATE DRAIN 1.

27 WHL-012 REV. 12.17.14 If using a condensate pump, select one

28 WHL-012 REV. 12.17.14 3. LP (Liquid Propane) Gas Pipe Sizing Th

29 WHL-012 REV. 12.17.14 Figure 16 – Gas Line with Shut-Off Valve

3 WHL-012 REV. 12.17.14 The following defined terms are used thro

30 WHL-012 REV. 12.17.14  To ease future maintenance isolation v

31 WHL-012 REV. 12.17.14 B. DHW PIPING Use both thread tape and pi

32 WHL-012 REV. 12.17.14 Figure 20 – CH and DHW Piping NOTES: 1.

33 WHL-012 REV. 12.17.14 Figure 21 – CH Piping – Zoning with Pump

34 WHL-012 REV. 12.17.14 Figure 22 – DHW Priority with Outdoor Re

35 WHL-012 REV. 12.17.14 D. CH AND DHW PRESSURE RELIEF VALVES An e

36 WHL-012 REV. 12.17.14 ELECTRICAL SHOCK HAZARD – To ensure saf

37 WHL-012 REV. 12.17.14 Figure 25 – Dip Switch Detail DIP SWITCH

38 WHL-012 REV. 12.17.14 Figure 26 – Electrical Wiring Diagram

39 WHL-012 REV. 12.17.14 Figure 27 – Ladder Diagram

4 WHL-012 REV. 12.17.14 FOREWORD This manual is intended to be use

40 WHL-012 REV. 12.17.14 CONNECTOR DESCRIPTION HT SELV NO. OF LOCA

41 WHL-012 REV. 12.17.14 CONNECTOR DESCRIPTION HT SELV NO. OF LOCA

42 WHL-012 REV. 12.17.14 PART 10 – OPERATING SYSTEM INSTRUCTIONS A

43 WHL-012 REV. 12.17.14 NOTE: The initial display screen will dif

44 WHL-012 REV. 12.17.14 Figure 33 – CH Set-Point Screen Factory

45 WHL-012 REV. 12.17.14 Press the button again to return to Ope

46 WHL-012 REV. 12.17.14 Display Default Detail Description 5: St

47 WHL-012 REV. 12.17.14 Display Default Detail Description 27:PE

48 WHL-012 REV. 12.17.14 Error Code Error Code Description Possibl

49 WHL-012 REV. 12.17.14 Error Code Error Code Description Poss

5 WHL-012 REV. 12.17.14 E. WATER QUALITY ...

50 WHL-012 REV. 12.17.14 K. ERROR TREE ANALYSIS 1. FLAME DETECTION

51 WHL-012 REV. 12.17.14 3. APS / BURNER OVERHEAT LIMIT / CONDENSA

52 WHL-012 REV. 12.17.14 Figure 42 – Outdoor Reset Curve – See In

53 WHL-012 REV. 12.17.14 PART 11 – START-UP PREPARATION Thoroughl

54 WHL-012 REV. 12.17.14 FOR YOUR OWN SAFETY READ BEFORE OPERATI

55 WHL-012 REV. 12.17.14 D. PURGE AIR FROM CH AND INTERNAL STORAGE

56 WHL-012 REV. 12.17.14 G. CONDENSATE REMOVAL 1. This is a high e

57 WHL-012 REV. 12.17.14 LP GAS NATURAL GAS Minimum Pressure 3.5”

58 WHL-012 REV. 12.17.14 PART 12 –INSTALLATION AND START-UP CHECKL

59 WHL-012 REV. 12.17.14 Figure 45 – Flame Sight Glass PART 13 –

6 WHL-012 REV. 12.17.14 B. LCD DISPLAY DESCRIPTIONS ...

60 WHL-012 REV. 12.17.14 DIAGNOSTICS AND SUGGESTED CORRECTIVE ACTI

61 WHL-012 REV. 12.17.14 Ensure the Appliance Cabinet is Closed E

62 WHL-012 REV. 12.17.14 Have leaks fixed at once by a qualified

63 WHL-012 REV. 12.17.14 7. Rinse the cleaning solution from the h

64 WHL-012 REV. 12.17.14 10. Remove the DHW inlet filter from the

65 WHL-012 REV. 12.17.14 condensate hose from the heat exchanger.

66 WHL-012 REV. 12.17.14 REPLACEMENT PARTS Figure 52 – Cabinet Re

67 WHL-012 REV. 12.17.14 Figure 53 – Combustion System Replacemen

68 WHL-012 REV. 12.17.14 Figure 54 – Water Piping Replacement Par

69 WHL-012 REV. 12.17.14 Limited Warranty for Combination Applian

7 WHL-012 REV. 12.17.14 PART 1 – ITEMS SHIPPED WITH THE APPLIANCE

70 WHL-012 REV. 12.17.14 17. Any damage or failure resulting from

71 WHL-012 REV. 12.17.14 START-UP REPORT LIGHT OFF ACTIVITIES DATE

72 WHL-012 REV. 12.17.14 MAINTENANCE REPORT In unusually dirty or

73 WHL-012 REV. 12.17.14

74 WHL-012 REV. 12.17.14

75 WHL-012 REV. 12.17.14 MAINTENANCE NOTES

76 WHL-012 REV. 12.17.14 CUSTOMER INSTALLATION RECORD FORM Th

8 WHL-012 REV. 12.17.14 OPTIONAL PARTS (Not Included) ITEM DESCR

9 WHL-012 REV. 12.17.14 DO NOT use spray paint, hair spray, or an